« previous next »
Pages: [1]   Go Down

Author Topic: very small plastering repair ideas  (Read 5771 times)

0 Members and 1 Guest are viewing this topic.

Offline paceman

  • Hard Top Camper User
  • ******
  • Posts: 3226
  • Thanked: 266 times
  • Gender: Male
very small plastering repair ideas
« on: August 25, 2015, 09:31:18 AM »
hi guys,

looking to get some ideas on how i could repair the following, without spending a fortune, and possibly be able to do it myself?




thoughts appreciated...
Logged

Offline plusnq

  • Hard Top Camper User
  • ******
  • Posts: 2204
  • Thanked: 233 times
Re: very small plastering repair ideas
« Reply #1 on: August 25, 2015, 09:41:48 AM »
Cheap and nasty or good?

Cheap and nasty would be glue some cardboard to rear and then fill with plaster rapid patch filler. May take a few coats then paint.
Logged
The following users thanked this post: paceman

Offline paceman

  • Hard Top Camper User
  • ******
  • Posts: 3226
  • Thanked: 266 times
  • Gender: Male
Re: very small plastering repair ideas
« Reply #2 on: August 25, 2015, 09:52:06 AM »
Quote from: plusnq on August 25, 2015, 09:41:48 AM
Cheap and nasty or good?

Cheap and nasty would be glue some cardboard to rear and then fill with plaster rapid patch filler. May take a few coats then paint.


it's behind the dunny, so it doesn't have to be perfect... :)

it's more to stop ants and other crawlies coming in there...

maybe something like this?

http://www.selleys.com.au/home-improvement/living-room-renovation/repair-a-hole-in-a-plaster-wall/
« Last Edit: August 25, 2015, 09:54:36 AM by paceman »
Logged

Offline HKB Electronics

  • Hard Top Camper User
  • ******
  • Posts: 2173
  • Thanked: 239 times
  • Gender: Male
  • www.hkbelect.com
    • HKB Electronics
Re: very small plastering repair ideas
« Reply #3 on: August 25, 2015, 09:59:22 AM »
Not a big problem, you'll need to remove the tap and make the hole large enough
that you can slip a couple of pieces of plaster board in behind the existing sheet,
on each side of the tap fitting to cover the hole. The pieces need to be bigger than
the hole so that their is overlap, this is called back blocking.

You then use cornice cement to glue the pieces in, ie screw a plaster screw into the
patch piece so that you can hold it, butter the edges of patch with cornice cement
and then insert it through the hole in the wall turn it around and pull it up against
the wall sheet to spread out the cement but leave a couple of mills depth for the cement
that will be used in the next step. If the patch piece is not to big it may just hang there
till the cement dries, if not then you'll need to support it till it does.

Once the back block is dry, cut another piece of plaster board that will just fit in the hole
and glue it in with cornice cement, when dry skim coat the area, you could tape the joins
before skim coating but I have never had any cracking occur for a small area that has
been back blocked.
Logged
HKB Electronics, manufacturer of the Alternator Voltage Boosters
The following users thanked this post: paceman

Offline achjimmy

  • Hard Top Camper User
  • ******
  • Posts: 3255
  • Thanked: 166 times
  • Gender: Male
Re: very small plastering repair ideas
« Reply #4 on: August 25, 2015, 10:13:21 AM »
Cornice cement will fill that amount no worries. Sand it back put on some topcoat if fussy or just paint. (After priming)
Logged
Here for a good time, not a long time!

Jim

Offline Murph

  • Tent User
  • ***
  • Posts: 216
  • Thanked: 7 times
Re: very small plastering repair ideas
« Reply #5 on: August 25, 2015, 10:15:28 AM »
Put a larger s/s cover plate behind the one that's there.
Logged
The following users thanked this post: paceman

Offline paceman

  • Hard Top Camper User
  • ******
  • Posts: 3226
  • Thanked: 266 times
  • Gender: Male
Re: very small plastering repair ideas
« Reply #6 on: August 25, 2015, 10:16:35 AM »
Quote from: achjimmy on August 25, 2015, 10:13:21 AM
Cornice cement will fill that amount no worries. Sand it back put on some topcoat if fussy or just paint. (After priming)

do you mean without taking the tap off?  how does it stay in place without a backing piece or fibreglass mesh?
Logged

Offline achjimmy

  • Hard Top Camper User
  • ******
  • Posts: 3255
  • Thanked: 166 times
  • Gender: Male
Re: very small plastering repair ideas
« Reply #7 on: August 25, 2015, 10:21:33 AM »
Yep a reasonably tacky mix will stick maybe need two goes as to thick and it will get cracks. Depends how fussy you wanna be? I have also put a bit of wood through with stud adhesive and pulled it back tight with a screw then filled it. Even if you patch it as all of the suggestions above chances are you will get hair cracks
Logged
Here for a good time, not a long time!

Jim
The following users thanked this post: paceman

Offline paceman

  • Hard Top Camper User
  • ******
  • Posts: 3226
  • Thanked: 266 times
  • Gender: Male
Re: very small plastering repair ideas
« Reply #8 on: August 25, 2015, 10:33:45 AM »
Quote from: Murph on August 25, 2015, 10:15:28 AM
Put a larger s/s cover plate behind the one that's there.

didn't think you could get a bigger one?

or are you talking about making my own?
Logged

Offline rags

  • Hard Floor Camper User
  • *****
  • Posts: 1116
  • Thanked: 196 times
  • Gender: Male
Re: very small plastering repair ideas
« Reply #9 on: August 25, 2015, 10:44:50 AM »
Quote from: paceman on August 25, 2015, 10:33:45 AM
didn't think you could get a bigger one?

or are you talking about making my own?

you will be able to get from a plumbing supplies or the green hardware a larger cover plate suitable for a 40mm or 50mm pipe ,usually white. You could then put a bit of silicant behind it and centre it over the  thread coming out of the wall and then replace the existing cover plate over the top.
Logged
The following users thanked this post: paceman

Offline prodigyrf

  • Hard Top Camper User
  • ******
  • Posts: 3755
  • Thanked: 187 times
  • Gender: Male
Re: very small plastering repair ideas
« Reply #10 on: August 25, 2015, 12:32:54 PM »
Logged
There's no Great Evil conspiracy against consumers within engineering, manufacturing and supply. Just the many tradeoffs incurred to satisfy diverse tastes, priorities and wallets. But first comes all the insatiable Gummint eggsperts, nanny-staters and usual suspects.

Offline krisandkev

  • Hard Floor Camper User
  • *****
  • Posts: 1421
  • Thanked: 69 times
Re: very small plastering repair ideas
« Reply #11 on: August 25, 2015, 12:42:11 PM »
I just replaced our cistern and ended up with two big holes where the old cistern was bolted to the wall with butterfly bolts.  I have just applied some plaster filler into the holes, not too much, just enough to allow me to apply a second amount when dry. When this is dry I will sand it off and paint.  Remember not to mound the filler up to much so you don’t have to sand a lot, just a light sanding with fine paper should do.  Both holes are just to the side of the new cistern so the filler will not have to be strong and once painted no one will know.   ;D  Kevin
Logged
Kris and Kev
2008 TTD Landcruiser 200 GXL, Aust Off Road Camper, 20ft Bushtracker.
The following users thanked this post: paceman

Offline prodigyrf

  • Hard Top Camper User
  • ******
  • Posts: 3755
  • Thanked: 187 times
  • Gender: Male
Re: very small plastering repair ideas
« Reply #12 on: August 25, 2015, 06:50:10 PM »
Seriously that's typical of gyprock fixers belting a hole in the board with a hammer to get it over the plumbing first fix and the flushers haven't covered for them. It's only cosmetic and the threaded breech  should be securely fixed to the wall stud.

Presumably you don't fancy turning the water off and removing the tap for a fix but you can remove the braided hose for easy access and then 2 choices with some bog (thick base coat, cornice adhesive or handyman spakfilla type bog) Shove newspaper in there to back the filler or you can further cut the hole larger in order to insert a rectangular piece of gyprock or scantling in it and turn it into place with a suitable screw handle to glue it the rear and then bog it.

Really depends on what you have in the armoury and newspaper and some handyman spakfilla would be simplest/cheapest. Just remember without soft final sanding filler you don't want to leave hard spakfillas, etc proud of the surface but build up the repair in stages to a smooth level finish that only needs a light finish sand. 
Logged
There's no Great Evil conspiracy against consumers within engineering, manufacturing and supply. Just the many tradeoffs incurred to satisfy diverse tastes, priorities and wallets. But first comes all the insatiable Gummint eggsperts, nanny-staters and usual suspects.
The following users thanked this post: paceman

Offline Rumpig

  • Hard Top Camper User
  • ******
  • Posts: 6053
  • Thanked: 527 times
Re: very small plastering repair ideas
« Reply #13 on: August 25, 2015, 07:11:18 PM »
Just grab a small tub of Selleys polyfilla and use that to fill the hole. Easy to sand once it dries, and dries pretty quickly also.
Logged
The smell of bacon proves aromatherapy isn't total bull$/!t
The following users thanked this post: paceman

Offline DJ Trailer

  • Sleeping Bag User
  • *
  • Posts: 25
  • Thanked: 1 times
Re: very small plastering repair ideas
« Reply #14 on: August 25, 2015, 08:24:31 PM »
Car bog works well for the holes my boys put in the gyrock

Logged
The following users thanked this post: paceman

Offline terravista

  • Soft Floor Camper User
  • ****
  • Posts: 574
  • Thanked: 25 times
  • Gender: Male
Re: very small plastering repair ideas
« Reply #15 on: August 27, 2015, 09:12:10 AM »
If you are not too fussed, you could get a piece of plastic like an ice cream container lid, cut your own overall shape and trim a hole in the middle the size of the existing cover plate. Slit one side so it flexes over the pipe, and glue the sucker on.
No plastering, and if you use a lid from a vanilla flavoured product you won't even need to paint it.
Logged
The following users thanked this post: paceman
Pages: [1]   Go Up
« previous next »